Product ID:ENGINE STARTING FLUID-DIESELMATIC,KOMPAC,2
MSDS Date:03/11/1992
FSC:5430
NIIN:01-292-1628
MSDS Number: BPCFM

KBI/KOLD BAN INTERNATIONAL LTD

900 PINGREE RD
LAKE IN THE HILLS (FORMERLY ALGONQUIN), IL 60102-9670
US

Emergency Phone: 847-658-8561

Info Phone: 847-658-8561

Cage: 53203

OSHKOSH TRUCK CORP

2566 OSHKOSH, WI 54903-2566 US

Telephone: 920-235-9151

Cage: 45152

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;93

ETHYL ETHER (SARA III)

CAS: 60-29-7

RTECS: KI5775000

OSHA PEL 400 PPM/500 STEL

ACGIH TLV: 400PPM/500STEL; 9293

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

HEPTANE

CAS: 142-82-5

RTECS: MI7700000

OSHA PEL 500 PPM/500 STEL

ACGIH TLV: 400 PPM/500STEL;9293

MINERAL OIL, SEVERELY HYDROTREATED, PREDOMINATELY

CAS: 64742-53-6

RTECS: PY8036000

OSHA PEL 5 MG/M3 OIL MIST

ACGIH TLV: 5 MG/M3 OIL MIST

LD50 LC50 Mixture:TLV FOR DIETHYL ETHER IS 400 PPM.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:MAY CAUSE IRRITATION.SKIN:MAY
CAUSE IRRITATION AND DRYNESS.INHALE:MAY CAUSE RESPIRATORY TRACT
IRRITATION AND NARCOSIS.INGEST:UNLIKELY ROUTE OF
EXPOSURE.ASPIRATION HAZARD.CHRONIC-MAY CAUSE DERMATIT IS.
Explanation of Carcinogenicity:THERE ARE NO CARCINOGENS PRESENT AT OR
ABOVE 0.1%.
Effects of Overexposure:EYE:TEARING,REDNESS &
CONJUNCTIVITIS.SKIN:DRYNESS.INHALATION OF VAPORS OR
MISTS:DIZZINESS, NAUSEA, VOMITING, HEADACHE. INGESTION:NAUSEA,
VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:PERSONS WITH CHRONIC RESPIRATORY OR
SKIN DISEASES MAY BE AT AN INCREASED RISK FROM EXPOSURE.

First Aid:GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. SKIN:WASH WITH
SOAP & WATER. EYE:FLUSH WITH WATER FOR 15 MINUTES, HOLDING EYELIDS
OPEN. INHALED:REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED.
ORAL: CAL L A PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY. PROPER
TREATMENT IS DEPENDENT ON CONDITION OF PATIENT AND AMOUNT INGESTED.

Flash Point:FLAMMBL AEROSOL
Lower Limits:1.8 (ETHER)
Upper Limits:48 (ETHER)
Extinguishing Media:CO2, WATER FOG, FOAM OR DRY CHEMICAL. WATER SPRAY
MAY BE USED TO KEEP FIRE EXPOSED CONTAINERS COOL & FLUSH SPILLS
AWAY.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND NIOSH-
APPROVED SELF-CONTAINED BREATHING APPARATUS WITH FULL FACEPIECE
OPERATED IN THE POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:EXTREMELY FLAMMABLE. OVERHEATED, CLOSED
CONTAINERS COULD EXPLODE DUE TO INTERNAL PRESSURE BUILDUP. VAPORS
MAY TRAVEL TO AN IGNITION SOURCE AND FLASH BACK.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT.ELIMINATE SOURCES OF
IGNITION.VENTILATE THE AREA.STOP LEAK IF POSSIBLE.CONTAIN THE
SPILL. COVER WITH ABSORBENT MATERIALS AS NEEDED.COLLECT THE SPILLED
MATERIAL USING NON-SPAR KING TOOLS.RUNOFF TO SEWERS MAY CAUSE
EXPLOSIONS.
Neutralizing Agent:NOT APPLICABLE.

Handling and Storage Precautions:STORAGE-STORE IN COOL,WELL VENTILATED
AREA AWAY FROM HEAT,SPARKS,OTHER SOURCES OF IGNITION & RESIDENTIAL
STRUCTURES.
Other Precautions:DO NOT STORE OVER 120F.PROTECT CONTAINER FROM
PHYSICAL DAMAGE.AVOID BREATHING VAPOR/MIST.AVOID CONTACT WITH EYES
& SKIN.FOR INDUSTRIAL USE ONLY.VAPORS CAN BE IGNITED EASILY.KEEP
AWAY FROM REACH OF CHI LDREN.

Respiratory Protection:NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR/
POWERED AIR-PURIFYING RESPIRATOR.FOR EMERGENCY USE SELF-CONTAINED
BREATHING APPARATUS/SUPPLIED-AIR RESPIRATOR WITH FULL FACEPIECE
OPERATED IN POSITIVE PRE SSURE MODE.
Ventilation:USE EXPLOSION-PROOF LOCAL VENTILATION EQUIPMENT.
Protective Gloves:NITRILE GLOVES
Eye Protection:CHEMICAL SAFETY GOGGLES
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING, APRON, AND BOOTS IF SPILLS OR
SPLASHING CAN OCCUR.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
NONE

HCC:G2
Boiling Pt:B.P. Text:94F (ETHER)
Vapor Pres:7758 @ 70F
Vapor Density:2.5
Spec Gravity:0.70
Evaporation Rate & Reference:7.0 (N-BUTYL ACETATE=1)
Solubility in Water:MODERATE;7% @ 70F
Appearance and Odor:AEROSOL.PALE YELLOW TO CLEAR LIQUID,STRONG ETHEREAL
ODOR
Percent Volatiles by Volume:99

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS AND CHEMICALS CAPABLE OF SPONTANEOUS HEAT OR
COMBUSTION.
Stability Condition to Avoid:HEAT,SPARKS,HOT SURFACES & OTHER SOURCES
OF IGNITION. TENDS TO PRODUCE EXPLOSIVE PEROXIDE ON LONG
STANDING+AIR+LIGHT.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.

Waste Disposal Methods:ALLOW SPILLS TO EVAPORATE OR INCINERATE ABSORBED
MATERIALS IN A LICENSED HAZARDOUS WASTE FACILITY. DISPOSAL SHOULD
BE IN ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS. DO
NOT PUNCTURE, MUTI LATE OR INCINERATE CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.